Page 1 of 3

X Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   BB026  
    Pre-opening
X Original Inspection
    Reinspection
   Follow-Up
    Possible FBI
    Complaint
   Other
Name of Establishment  JOE'S CATERING INC. D/B/A/ TUCCI'S ITALIAN Address  1560 STATE RT. 50 NORTH
Owner or Operator   JOE'S CATERING, INC. City   BOURBONNAIS Zip Code   60914
 
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
 
FOOD
18
 
1
 Pre-flushed, scraped, soaked
34
X
1
 Outside storage area, enclosures properly constructed, clean: controlled incineration
*1
  
5
 Source, Wholesome, No Spoilage
19
  
2
 Wash, rinse after: clean, proper temperature
2
X
1
 Original Container, Properly Labeled
*20
  
4
 Sanitization rinse: Clean, temperature, concentration   INSECT, RODENT ANIMAL CONTROL
 
FOOD PROTECTION
*35
  
4
 Presence of insects/rodents - outer openings protected; no birds, turtles, or other animals
*3
X
5
 Potentially hazardous food meets temperature requirements during storage, preparation, display, service and transportation
21
X
1
 Wiping cloths: clean, use restricted
22
X
2
 Food contact surfaces of equipment and utensils clean, free of abrasives and detergents  
FLOORS WALLS AND CEILINGS
36
X
1
 Floor: constructed, drained, clean, good repair, covering installation, dustless cleaning methods
*4
  
4
 Facilities to maintain product temperature
23
X
1
 Non-food contact surfaces of equipment and utensils clean
5
 
1
 Thermometers provided and conspicuous
37
X
1
 Walls, ceiling, attached equipment: constructed good repair, clean surfaces, dustless cleaning methods
6
 
2
 Potentially hazardous food properly thawed
24
  
1
 Storage, handling of clean equipment utensils
*7
  
4
 Unwrapped and potentially hazardous food not re-served, Cross Contamination
25
  
1
 Single-service articles, storage, dispensing  
LIGHTING
26
  
2
 No re-use of single-service articles
38
  
1
 Lighting provided as required - Fixtures shielded
8
X
2
 Food protection during storage, preparation, display, service and transportation  
WATER
  
VENTILATION
*27
 
5
 Water source, safe: Hot and cold under pressure
39
  
1
 Rooms and equipment - vented as required
9
  
2
 Handling of food(ice) minimized, methods  
SEWAGE
  
DRESSING ROOMS
10
X
1
 Food(ice) dispensing utensils properly stored
*28
  
4
 Sewage and waste water disposal
40
  
1
 Rooms clean, lockers provided, facilities clean
 
PERSONNEL
  
PLUMBING
  
OTHER OPERATIONS
*11
  
5
 Personnel with infections restricted
29
  
1
 Installed, maintained
*41
  
5
 Toxic items properly stored, labeled and used
*12
  
5
 Hands washed and clean, good hygienic practices
*30
 
5
 Cross-connection, back siphonage-backflow
42
  
1
 Premises: maintained, free of litter, unnecessary articles, cleaning/maintenance equipment properly stored, authorized personnel
13
  
1
Clean clothes, hair restraints
  
TOILET AND HAND-WASHING FACILITIES
 
FOOD EQUIPMENT AND UTENSILS
14
X
2
 Food (ice) contact surfaces: designed, constructed, maintained, installed, located
*31
X
4
 Number, convenient, accessible, designed, installed
43
  
1
 Complete separation from living/sleeping quarters, laundry
32
X
2
 Toilet rooms enclosed, self-closing doors, fixtures, good repair, clean: Hand cleanser, sanitary towels/hand drying devices provided. Proper waste receptacles, tissue
15
X
1
 Non-food (ice) contact surfaces: designed, constructed, maintained, installed, located.
44
  
1
 Clean, soiled linen properly stored
 
CERTIFIED PERSONNEL
16
  
2
 Dishwashing facilities: designed, constructed, maintained, installed, located, operated
*45
     Management personnel certified Yes X No     Registered for class    
 
GARBAGE AND REFUSE DIPSOSAL
17
  
1
 Accurate thermometers, chemical test kits provided, gauge cook
33
X
2
 Containers or receptacles covered: adequate number, insect/rodent proof, frequency, clean
 
      
Sanitizer Requirement:  Chemical   QUAT 200-400 ppm                   Dishwasher Temperature   180 F °F or label
Food Temperatures:   HAM 39, CHEESE 39, BEANS 40, GRAVY 39, LASAGNA 38, CAKE 38, BROWN GRAVY 39, SAUSAGE 37, RAW STEAK 36, PASTA 37, CHEESE 40, OLIVES 40, PEPPERONI 35, MARINARA 36
 
General Comments
HACCP CONCEPTS DISCUSSED: KEEP TIME AND DATE ON ALL FOODS TO KNOW THAT IT IS COOLED DOWN WITHIN 6 HOURS TO GET IT OUT OF THE DANGER ZONE ASAP. 
Report and Instructions Received By   ANTONIO /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  12/14/2015 Time In  1:30 PM Time Out  3:25 PM Sanitation Score  73 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  82  
 
Page 2 of 3

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   BB026  
    Pre-opening
X Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  JOE'S CATERING INC. D/B/A/ TUCCI'S ITALIAN Address  1560 STATE RT. 50 NORTH
Owner or Operator   JOE'S CATERING, INC. City   BOURBONNAIS Zip Code   60914
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
*3  Observed the following potentially hazardous foods to be held at improper temperatures. Raw chicken was found at 50F. Provide for all cold potentially hazardous foods to be held at 41°F or below at all times except during necessary periods of preparation. 750.120 Immediate/Onsite
*31  Observed the following hand sink(s) to be inaccessible: Hand sink in kitchen and in wait area was blocked by trash can brooms etc. All this equipment was removed. Provide for all handsinks to be accessible at all times to assure that proper handwashing occurs. 750.1120 Immediate/Onsite
2  Observed the following food products to have improper/no labeling information. There is no time & date on lasagna, beans, gravy etc. Provide for all foods to have proper labeling information. 750.100 Next Inspection
8  Observed the following food products to be improperly stored.1. There is no lids on soup in the walk-in cooler or at warming units on main prep line. 2. No lid on powdered sugar or brown sugar. Provide for all food products in storage to have proper covers or overhead protection. 750.130 Next Inspection
10  Observed the following utensil(s) to be improperly stored. 1. Handle found in cheese at pizza station. 2. Handle found in ice in ice bin located in bar. Provide for all utensils to be stored in one of the following manners: 1) Clean and dry 2) In the food product with the handle up and out of the food product 3) In a dipper well, using potable water 4) Malt collars and frozen dessert utensils either clean and dry or in a dipper well. 750.280 Next Inspection
14  Observed the following improper food contact surfaces. Cutting boards has a lot of knife grooves in them. Provide for all food contact surfaces to be smooth, easily cleanable, non-absorbent, corrosive resistant, and light colored. 750.650 Next Inspection
15  Observed the following improper non-food contact surfaces. Tin foil was found on shelves where pizza pans are located. Provide for all food contact surfaces to be smooth, easily cleanable, non-absorbent, corrosive resistant, and light colored. 750.690 Next Inspection
21  Observed the following wiping cloth(s) to be improperly stored: Found soiled wiping cloths on prep tables. Provide for all wiping cloths to be stored completely submerged in an approved sanitizer solution while not being used. 750.820 Next Inspection
22  Observed the following food contact surfaces to be unclean. Beer cooler has water at the bottom of it. Clean and maintain. 750.800 Next Inspection
23  Observed the following contact surfaces to be unclean. 1. Interior of fryer has grease & debris in them. 2. Sides of fryers has grease & debris on them. 3. Plate shelf has food debris on it. Clean and maintain. 750.800 Next Inspection
32  Observed the following fixtures to be in poor repair in the restroom(s): Tank lid is broken in Men's employee restroom. Provide for all fixtures to be kept clean and in good repair. 750.1120 Next Inspection
33  Observed dumpster lids were open. Keep all dumpster lids shut. 750.1150 Next Inspection
34  Observed the dumpster area to be unclean. There Is leaves & debris around the dumpster. Provide for the dumpster area to be kept clean so as to not be an attractive nuisance. 750.1140 Next Inspection
36  Observed the following floor areas to be unclean: 1. Floor in kitchen has debris on it. Provide for all flooring areas to be in a clean condition. 750.1220 Next Inspection
37  Observed the following wall/ceilings, and attached equipment to be unclean: 1. Wall by warming units has food debris on it. 2. Wall behind fryers and to the right of left of fryers has grease & debris on it. Provide for all walls, ceilings, and attached equipment to be in a clean condition. 750.1220 Next Inspection
     
     
Report and Instructions Received By   ANTONIO /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  12/14/2015 Time In  1:30 PM Time Out  3:25 PM Sanitation Score  73 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  82  
 
Page 3 of 3

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   BB026  
    Pre-opening
X Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  JOE'S CATERING INC. D/B/A/ TUCCI'S ITALIAN Address  1560 STATE RT. 50 NORTH
Owner or Operator   JOE'S CATERING, INC. City   BOURBONNAIS Zip Code   60914
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
     
     
     
     
Report and Instructions Received By   ANTONIO /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  12/14/2015 Time In  1:30 PM Time Out  3:25 PM Sanitation Score  73 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  82